Research of Key Technologies for n-i-p Perovskite Solar Cells With SnO2 Electron Transport Layer

doi:10.12096/j.2096-4528.pgt.22072

Abstract

Abstract:

Perovskite solar cells (PSCs) have attracted extensive attentions due to their high-efficiency, simple preparation process and low-cost. The efficiency of the PSCs has increased from 3.8% to 25.7%. So far, more and more studies focus on n-i-p structured PSCs using SnO₂ as electron transport layer. However, its process reproducibility is relatively poor, and efficiency is still low. This report conducted a systematic study of planar n-i-p PSCs, mainly including the selection of transparent conductive oxide (TCO) glass, optimization of preparation parameters and the influence of storage conditions on device performance. Experimental results show that these parameters have an important impact on the device performance. At the same time, it was analyzed by scanning electron microscope, X-ray diffraction, absorption spectrum. The devices achieved an average efficiency of 21.85% and a highest efficiency of 23.47% with good reproducibility under the optimal conditions (Indium Tin oxide substrate, PbI₂ annealed at 70 ℃ for 1 min, standing time after dropping amine salt solution is less than 5 s, and stored in 4.5% humidity environment). This work provides scientific support for the preparation of high-efficiency and repeatable PSCs.

Key words: perovskite solar cells (PSCs), n-i-p, SnO₂, high-efficiency, reproducibility

CLC Number:

TK 01

Xiaopeng YUE, Xing ZHAO, Huilin YAN, Bingbing FAN, Hao HUANG, Luyao YAN, Peng CUI, Junfeng MA, Meicheng LI. Research of Key Technologies for n-i-p Perovskite Solar Cells With SnO₂ Electron Transport Layer[J]. Power Generation Technology, 2023, 44(1): 63-77.

Figures/Tables 28

Fig. 1 Schematic diagram of PSCs structure

Fig. 2 Box comparison diagram of performance parameters of PSCs based on FTO and ITO substrates

Fig. 3 J-V curves of the optimal PSCs based on FTO and ITO substrates

Tab. 1 Best performing photovoltaic parameters of PSCs based on FTO and ITO substrates

TCO	J_sc/（mA/cm²）	V_oc/V	F_F/%	P_CE/%
FTO	22.34	1.11	71.73	17.78
ITO	23.27	1.11	75.43	19.47

Fig. 4 Box distribution diagram of performance parameters of PSCs at different annealing temperatures of PbI2

Fig. 5 J-V curves of optimal PSCs annealed at different annealing temperatures of PbI2

Tab. 2 Best performing photovoltaic parameters of PSCs at different annealing temperatures of PbI2

T/℃	J_sc/（mA/cm²）	V_oc/V	F_F/%	P_CE/%
65	19.55	1.06	71.18	14.86
70	23.77	1.14	75.05	20.26
75	24.12	1.10	73.44	19.42

Fig. 6 Perovskite film SEM images based on PbI2 at different annealing temperatures

Fig. 7 Absorption spectra of perovskite thin films prepared by PbI2 at different annealing temperatures

Fig. 8 Perovskite XRD spectrum at different annealing temperatures of PbI2

Fig.9 Box diagram of performance parameters of PSCs under different annealing time of PbI2 at 70 ℃

Fig. 10 J-V curves of the optimal PSCs under different annealing time of PbI2 at 70 ℃

Tab. 3 Best performing photovoltaic parameters of PSCs based on PbI2 annealed at 70 ℃ with different annealing time

t/s	J_sc/（mA/cm²）	V_oc/V	F_F/%	P_CE/%
55	23.27	1.11	75.43	19.47
60	23.77	1.14	75.05	20.26
65	23.73	1.10	75.11	19.54

Fig. 11 Perovskite film SEM images based on PbI2 at different annealing time of 70 ℃

Fig. 12 Absorption spectra of perovskite thin films based on PbI2 annealed at 70 ℃ with different annealing time

Fig. 13 Perovskite XRD spectrum under different annealing time of PbI2 at 70 ℃

Fig. 14 Box diagram of performance parameters of PSCs under different standing time after dropping amine salt solution

Tab. 4 Best performing photovoltaic parameters of PSCs under different standing time after dropping amine salt solution

t/s	J_sc/（mA/cm²）	V_oc/V	F_F/%	P_CE/%
0	24.17	1.16	79.57	22.26
5	24.21	1.16	78.80	22.07
10	24.21	1.11	79.56	21.29

Fig. 15 J-V curves of optimal PSCs under different standing time after dropping amine salt solution

Fig. 16 Perovskite film SEM images under different standing time after dropping amine salt solution

Fig. 17 Absorption spectra of perovskite thin films obtained after dripping amine salt solution for different standing time

Fig. 18 Perovskite XRD spectrum under different standing time after dropping amine salt solution

Fig.19 Distribution diagram of performance parameters of PSCs under different storage humidity conditions

Tab. 5 Photovoltaic parameters of PSCs under different storage humidity conditions

相对湿度/%	测试时间	J_sc/(mA/cm²)	V_oc/V	F_F/%	P_CE/%
4.5	初始值	23.61	1.16	78.90	21.56
4.5	1天后	24.11	1.16	76.56	21.36
20	初始值	23.50	1.11	69.84	18.14
20	1天后	23.60	1.05	48.77	12.12

Fig. 20 J-V curves change of optimal PSCs under different storage humidity conditions

Fig. 21 Box diagram comparison of performance parameters of 15 PSCs scanned at forward and backward direction using optimized processes

Fig. 22 Photovoltaic performance of champion PSCs under optimal condition

Tab. 6 Photovoltaic parameters of champion PSCs under optimal condition

冠军电池	J_sc/（mA/cm²）	V_oc/V	F_F/%	P_CE/%
反扫	24.82	1.144	79.76	22.65
正扫	24.89	1.161	81.19	23.47

References 32

1	CHU S， MAJUMDAR A ．Opportunities and challenges for a sustainable energy future[J]．Nature，2012，488(7411)：294-303． doi:10.1038/nature11475
2	李春曦，王佳，叶学民，等．我国新能源发展现状及前景[J]．电力科学与工程，2012，28(4)：1-8． doi:10.3969/j.issn.1672-0792.2012.04.001
	Li C X， Wang J， Ye X M，et al ．Development and prospects of new energy in China[J]．Electric Power Science and Engineering，2012，28(4)：1-8． doi:10.3969/j.issn.1672-0792.2012.04.001
3	韩芳．我国可再生能源发展现状和前景展望[J]．可再生能源，2010，28(4)：137-140． doi:10.3969/j.issn.1671-5292.2010.04.033
	HAN F ．Development status and prospect of renewable energy in China[J]．Renewable Energy Resources，2010，28(4)：137-140． doi:10.3969/j.issn.1671-5292.2010.04.033
4	丁峰，李晓刚，梁泽琪，等．国外可再生能源发展经验及其对我国相关扶持政策的启示[J]．电力建设，2022，43(9)：1-11． doi:10.12204/j.issn.1000-7229.2022.09.001
	DING F， LI X G， LIANG Z Q，et al ．Review of foreign experience in promoting renewable energy development and inspiration to China[J]．Electric Power Construction，2022，43(9)：1-11． doi:10.12204/j.issn.1000-7229.2022.09.001
5	姜红丽，刘羽茜，冯一铭，等．碳达峰、碳中和背景下“十四五”时期发电技术趋势分析[J]．发电技术，2021，43(1)：54-64．
	Jiang H L， Liu Y X， Feng Y M，et al ．Analysis of power generation technology trend in 14th five-year plan under the background of carbon peak and carbon neutrality[J]．Power Generation Technology，2021，43(1)：54-64．
6	童光毅．基于双碳目标的智慧能源体系构建[J]．智慧电力，2021，49(5)：1-6． doi:10.3969/j.issn.1673-7598.2021.05.002
	TONG G Y ．Construction of smart energy system based on dual carbon goal[J]．Smart Power，2021，49(5)：1-6． doi:10.3969/j.issn.1673-7598.2021.05.002
7	刘斌，谈竹奎，唐赛秋，等．基于数据预测启发式算法的光伏电池参数识别[J]．电力系统保护与控制，2021，49(23)：72-79．
	LIU B， TAN Z K， TANG S Q，et al ．Photovoltaic cell parameter extraction using data prediction based on a meta-heuristic algorithm[J]．Power System Protection and Control，2021，49(23)：72-79．
8	National Renewable Energy Laboratory ．Best research-cell efficiency chart[EB/OL]．[2022-03-12]．．
9	Meng L， You J， Yang Y ．Addressing the stability issue of perovskite solar cells for commercial applications[J]．Nature Communications，2018，9(1)：5265． doi:10.1038/s41467-018-07255-1
10	Roy P， Kumar Sinha N， Tiwari S，et al ．A review on perovskite solar cells：Evolution of architecture，fabrication techniques，commercialization issues and status[J]．Solar Energy，2020，198：665-688． doi:10.1016/j.solener.2020.01.080
11	Reddy S H， Di Giacomo F， Di Carlo A ．Low‐temperature‐processed stable perovskite solar cells and modules：a comprehensive review[J]．Advanced Energy Materials，2022：2103534． doi:10.1002/aenm.202103534
12	Kojima A， Teshima K， Shirai Y，et al ．Organometal halide perovskites as visible-light sensitizer for photovoltaic cells[J]．Journal of American Chemical Society，2009，131：6050-6051． doi:10.1021/ja809598r
13	Kim H S， Lee C R， Im J H，et al ．Lead iodide perovskite sensitized all-solid-state submicron thin film mesoscopic solar cell with efficiency exceeding 9%[J]．Scientific Reports，2012，2：591-598． doi:10.1038/srep00591
14	Li Y， Xie H， Lim E L，et al ．Recent progress of ctical interface engineering for highly efficient and stable perovskite solar cells[J]．Advanced Energy Materials，2022，12(5)：1-31． doi:10.1002/aenm.202102730
15	Jiang Q， Zhang X， You J ．SnO₂ ：a wonderful electron transport layer for perovskite solar cells[J]．Small，2018：1801154． doi:10.1002/smll.201801154
16	Park S Y， Zhu K ．Advances in SnO₂ for efficient and stable n‐i‐p perovskite solar cells[J]．Advanced Materials，2022：2110438． doi:10.1002/adma.202110438
17	Song J， Zheng E， Wang X F，et al ．Low-temperature-processed ZnO-SnO₂ nanocomposite for efficient planar perovskite solar cells[J]．Solar Energy Materials and Solar Cells，2016，144：623-630． doi:10.1016/j.solmat.2015.09.054
18	Anaraki E H， Kermanpur A， Steier L，et al ．Highly efficient and stable planar perovskite solar cells by solution-processed tin oxide[J]．Energy and Environmental Science，2016，9(10)：3128-3134． doi:10.1039/c6ee02390h
19	Yoo J J， Seo G， Chua M R，et al ．Efficient perovskite solar cells via improved carrier management[J]．Nature，2021，590(7847)：587-593． doi:10.1038/s41586-021-03285-w
20	Min H， Lee D Y， Kim J，et al ．Perovskite solar cells with atomically coherent interlayers on SnO₂ electrodes[J]．Nature，2021，598(7881)：444-450． doi:10.1038/s41586-021-03964-8
21	Jiang Q， Zhao Y， Zhang X，et al ．Surface passivation of perovskite film for efficient solar cells[J]．Nature Photonics，2019，13(7)：460-466． doi:10.1038/s41566-019-0398-2
22	Jiang Q， Zhang L， Wang H，et al ．Enhanced electron extraction using SnO₂ for high-efficiency planar-structure HC(NH₂)₂ PbI₃-based perovskite solar cells[J]．Nature Energy，2017，2(1)：16177． doi:10.1038/nenergy.2017.60
23	Jiang Q， Chu Z， Wang P，et al ．Planar-structure perovskite solar cells with efficiency beyond 21%[J]．Advanced Materials，2017，1703852：1-7． doi:10.1002/adma.201703852
24	Liu D， Zheng H， Ahmed Y，et al ．Enhanced photovoltaic performance of SnO₂ based flexible perovskite solar cells via introducing interfacial dipolar layer and defect passivation[J]．Journal of Power Sources，2022，519：230814． doi:10.1016/j.jpowsour.2021.230814
25	Xiong Z， Chen X， Zhang B，et al ．Simultaneous interfacial modification and crystallization control by biguanide hydrochloride for stable perovskite solar cells with PCE of 24.4%[J]．Advanced Materials，2022，34(8)：1-10． doi:10.1002/adma.202106118
26	Yu X， Lv Y， Xue B，et al ．Multiple bonding effects of 1-methanesulfonyl-piperazine on the two-step processed perovskite towards efficient and stable solar cells[J]．Nano Energy，2022，93：106856． doi:10.1016/j.nanoen.2021.106856
27	LU H， KRISHNA A， ZAKEERUDDIN S M，et al ．Compositional and interface engineering of organic-inorganic lead halide perovskite solar Cells[J]．iScience，2020，23(8)：1-14． doi:10.1016/j.isci.2020.101359
28	ZHANG F， ZHU K ．Additive engineering for efficient and stable perovskite solar cells[J]．Advanced Energy Materials，2020，10(13)：1-26． doi:10.1002/aenm.201902579
29	LI T， RUI Y， ZHANG X，et al ．Anatase TiO₂ nanorod arrays as high-performance electron transport layers for perovskite solar cells[J]．Journal of Alloys and Compounds， 2020， 849： 156629． doi:10.1016/j.jallcom.2020.156629
30	ZHANG M， WILKINSON B， LIAO Y，et al ．Electrode design to overcome substrate transparency limitations for highly efficient 1 cm² mesoscopic perovskite solar cells[J]．Joule，2018，2(12)：2694-2705． doi:10.1016/j.joule.2018.08.012
31	CHEN Y， MENG Q， XIAO Y，et al ．Mechanism of PbI₂ in situ passivated perovskite films for enhancing the performance of perovskite solar cells[J]．ACS Applied Materials and Interfaces，2019，11(47)：44101-44108． doi:10.1021/acsami.9b13648
32	HU L， SHAO G， JIANG T，et al ．Investigation of the interaction between perovskite films with moisture via in situ electrical resistance measurement[J]．ACS Applied Materials and Interfaces，2015，7(45)：25113-25120． doi:10.1021/acsami.5b06268

[1]	Xin YUAN, Jun LIU, Heng CHEN, Peiyuan PAN, Gang XU, Xiuyan WANG. Effect of Carbon Capture Technology Application on Peak Shaving Capacity of Coal-Fired Units [J]. Power Generation Technology, 2024, 45(3): 373-381.
[2]	Jiahai YUAN, Yuelin HU, Jian ZHANG. The Carbon Emission Efficiency of China’s Listed Thermal Power Companies: An Improved Three-Stage Slack Based Measure-Data Envelopment Analysis Model [J]. Power Generation Technology, 2024, 45(3): 458-467.
[3]	Mingyi ZHANG, Peng HUANG, Yawu WANG. Research on Output Characteristics of a Circular Dielectric Elastomer Generator [J]. Power Generation Technology, 2024, 45(3): 517-526.
[4]	Jianqiang YE, Dunhu SUN. Research on Power Planning Based on Robust Optimization Under Carbon Trading Condition [J]. Power Generation Technology, 2024, 45(3): 566-574.
[5]	Lu GUO, Yongli LIU, Yuan ZHANG, Qian WU, Yuehui LI, Xiaoyu HOU, Yajing ZHANG. Application of Practical Data Synchronization Technology in Multi Person Cooperation Mechanism of New Distribution System Planning [J]. Power Generation Technology, 2024, 45(2): 363-372.
[6]	Hongjun FU, Shaoxuan ZHU, Buhua WANG, Yan XIE, Haoqing XIONG, Xiaojun TANG, Xiaoyong DU, Chenghao LI, Xiaomeng LI. Risk Prediction Method of Low Frequency Oscillation in Maintenance Power Network Based on Long Short Term Memory Neural Network [J]. Power Generation Technology, 2024, 45(2): 353-362.
[7]	Xiaobiao FU, Jiaqi HOU, Baoju LI, Yakun WEN, Xiaowen LAI, Lei GUO, Zhiwei WANG, Yao WANG, Haifeng ZHANG, Dexin LI. A Two-Modal Weather Classification Method and Its Application in Photovoltaic Power Probability Prediction [J]. Power Generation Technology, 2024, 45(2): 299-311.
[8]	Zheng YANG, Yipeng SUN, Zhiqiang WEN, Liang CHENG, Zhanguo LI. Research on Dry-Wet Conversion Strategy of Supercritical Thermal Power Units Under Deep Peaking Condition [J]. Power Generation Technology, 2024, 45(2): 233-239.
[9]	Zhan LI, Zhenyong YANG, Lei LIU, Zhensan CHEN, Weiming JI, Feng HONG. Analysis of the Influence of Furnace Side Heat Storage Coefficient on Primary Frequency Modulation Capacity Under Deep Modulation Condition of Thermal Power Unit [J]. Power Generation Technology, 2024, 45(2): 226-232.
[10]	Fangfang WANG, Pengwei YANG, Guangjin ZHAO, Qi LI, Xiaona LIU, Shuangchen MA. Development and Challenge of Flexible Operation Technology of Thermal Power Units Under New Power System [J]. Power Generation Technology, 2024, 45(2): 189-198.
[11]	Xiangyu WANG, Wuhui CHEN, Xiaolong GUO, Xiqiang CHANG. Review of Research on the Digitalization of Power Generation System [J]. Power Generation Technology, 2024, 45(1): 120-141.
[12]	Hongbo LIU, Shencheng LIU, Xueyang GAI, Yongfa LIU, Yutong YAN. Overview of Active Distribution Network Planning With High Proportion of New Energy Access [J]. Power Generation Technology, 2024, 45(1): 151-161.
[13]	Yeqing ZHANG, Wenbin CHEN, Lüjun XU, Xingwen JIANG. Multi-Virtual Power Plant-Oriented Dynamic Aggregation Control Strategy Based on Hierarchical Partition and Multi-Layer Complementation [J]. Power Generation Technology, 2024, 45(1): 162-169.
[14]	Minghui KE, Lin LAI. Experimental Research of Electrogasdynamic Power Generation With Exposed Electrode Structure Based on Normal Temperature Air [J]. Power Generation Technology, 2024, 45(1): 180-188.
[15]	Ruowei WANG, Yinxuan LI, Weichun GE, Shitan ZHANG, Chuang LIU, Shuai CHU. Summary of Desert Photovoltaic Power Transmission Technology [J]. Power Generation Technology, 2024, 45(1): 32-41.

Research of Key Technologies for n-i-p Perovskite Solar Cells With SnO₂ Electron Transport Layer

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

Figures/Tables 28

References 32

Related Articles 15

Recommended Articles

Metrics