煤炭联合制样设备性能调整及检验

doi:10.3969/J.ISSN.2095-3429.2017.06.001

发电技术 ›› 2017, Vol. 38 ›› Issue (6): 1-4.DOI: 10.3969/J.ISSN.2095-3429.2017.06.001

• 发电技术 • 下一篇

煤炭联合制样设备性能调整及检验

田建亮^1,2, 王伟³

1. 华电集团北京燃料物流有限公司河北分公司, 河北石家庄 050010;
2. 中国华电集团公司河北分公司, 河北石家庄 050010;
3. 中国华电集团公司, 北京 100031

收稿日期:2017-10-11 出版日期:2017-12-30 发布日期:2017-12-30
作者简介:田建亮(1973-),男,山东青岛人,助理工程师,主要从事火电厂燃煤管理工作。

Performance Adjustment and Test of Combined Coal Preparation Equipment

TIAN Jianliang^1,2, WANG Wei³

1. Hebei Branch, Huadian Corporation Beijing Fuel Logistics Corporation LTD., Shijiazhuang 050010, China;
2. Hebei Branch, China Huadian Corporation, Hebei Shijiazhuang 050010, China;
3. China Huadian Corporation, Beijing 100031, China

Received:2017-10-11 Published:2017-12-30 Online:2017-12-30

摘要/Abstract

摘要： 煤炭联合制样设备已经在煤炭、燃煤火电等领域广泛应用,其性能偏差可能会导致煤炭贸易纠纷,影响锅炉燃烧安全经济性。对某台检验存在性能偏差的联合制样设备进行检查,阐述了设备静态检查和动态检查的过程,根据检查中发现的问题对设备进行调整,消除了设备关键部件的缺陷,重新确定了出料粒度和缩分比等技术参数。设备调整后根据相关技术标准对其性能进行检验,通过精密度、系统偏倚和辅助试验对联合制样设备性能进行了综合评价,结果表明该设备经调整,性能达到相关标准的要求。

关键词: 煤炭, 联合制样设备, 调整, 检验

Abstract: Coal combined sample equipment has been widely used in coal,coal-fired power plants and other fields, and its performance deviation may lead to coal trade disputes, which affect the safety and economy of boiler combustion. The paper describes the inspection of combined coal preparation equipment with performance deviation, and iuugrates the process of static and dynamic examination of equipment inspection. By adjusting the equipment, the defects of key parts of the equipment were eliminated, particle size and the reduction ratio of technical parameters were redfined. According to the performance test of relevant technical standards, the equipment performance was evaluated through auuracy, system bias and supplemental tests. The equipment meets the requirements of relevant standards.

Key words: coal, combined sample preparation equipment, performance adjustment, test

中图分类号:

TQ520

田建亮, 王伟. 煤炭联合制样设备性能调整及检验[J]. 发电技术, 2017, 38(6): 1-4.

TIAN Jianliang, WANG Wei. Performance Adjustment and Test of Combined Coal Preparation Equipment[J]. Power Generation Technology, 2017, 38(6): 1-4.

[1]	丁湧. 1 000 MW超超临界燃煤锅炉深度调峰研究[J]. 发电技术, 2024, 45(3): 382-391.
[2]	胡胜林,李源,毛睿,詹胜平,任利明,郭志成,岑可法. 低氮改造后再热汽温偏低的燃烧调整研究[J]. 发电技术, 2019, 40(5): 475-480.
[3]	孙献斌,戚峰,辛以振,袁文杰,高永翔,郝如平,曹林涛,郭安. 330 MW循环流化床锅炉燃烧调整试验研究[J]. 发电技术, 2019, 40(3): 281-285.
[4]	崔修强. 碗式中速磨煤机运行特性试验研究及应用[J]. 发电技术, 2019, 40(2): 187-191.
[5]	王甲安,王兴合,张瑞臣,贺军,马龙信,郭佳雷. 火电机组EH油管道泄漏典型案例分析及防范措施[J]. 发电技术, 2018, 39(4): 382-385.
[6]	杨明印,冯仁海. 脱硝热解炉结晶的处理方法和预防措施[J]. 发电技术, 2018, 39(3): 249-252.
[7]	徐鹏志, 刘朋彬, 陈军华, 车方. 660MW锅炉低氮旋流燃烧器NOx排放调整试验研究[J]. 发电技术, 2017, 38(5): 16-21.
[8]	张磊, 秦岭, 包军, 陈剑, 李小江. 燃煤电厂储煤自燃倾向特性试验研究[J]. 发电技术, 2017, 38(3): 10-13.
[9]	郝晨光, 王勇, 周宇昊. 基于拟合优度检验的连杆疲劳可靠性分析[J]. 发电技术, 2017, 38(2): 12-15.
[10]	赵卫. 电煤价格影响因素及预测分析[J]. 发电技术, 2017, 38(2): 1-6.

煤炭联合制样设备性能调整及检验

Performance Adjustment and Test of Combined Coal Preparation Equipment

PDF (PC)

可视化

摘要/Abstract

引用本文

参考文献

相关文章 10

编辑推荐

Metrics